Royal Dutch Shell Plc  .com Rotating Header Image

Shell fined for leak on platform where workers died

Screen Shot 2015-07-02 at 08.21.39

Screen Shot 2015-07-02 at 08.26.33

Screen Shot 2015-07-02 at 08.28.32Thursday 2nd July 2015

Oil giant Shell has been fined more than £6,000 after a diesel leak on board the same North Sea platform where two workers died 12 years ago.

Sean McCue, 22, and Keith Moncrieff, 45, lost their lives when they were overcome by gas while working on the energy firm’s Brent Bravo rig in 2003.

The oil company was previously fined nearly £1 million after admitting safety breaches which led to their deaths.

Yesterday Shell UK bosses returned to the court after approximately 13 to 15 tonnes of diesel spilled into the North Sea despite warnings over the transfer system going back over a decade. Senior management from the Royal Dutch Shell subsidiary appeared in the public benches at Aberdeen Sheriff Court where the company pleaded guilty to an unlicensed release of fuel.

The leak took place in May 2013 while the Brent Bravo platform, which sits 116 miles north east of Lerwick, Shetland, underwent a scheduled shutdown for routine maintenance.

An offshore supply vessel was carrying out “bunkering” operations – using bulk hoses which are lowered from the platform to allow the transfer of diesel – when the leak was spotted on one of the flexible pipes.

Just before starting the transfer at about 1am on 11 May, 2013, the crews carried out inspections of the hoses but only noticed general “wear and tear”.

But around an hour later the chief officer of the supply vessel noticed a “discolouration” in the seawater indicating a leak.

The Crown narrative lodged in court yesterday stated: “He saw a plume emanating from the diesel bunkering hose which was mushroom-shaped and approximately 15-20 metres in length from the hose.

“He immediately instructed his crew to stop the diesel pump and contacted the Brent Bravo to advise them of the leak.

“The deck crew began pulling the diesel hose back to the installation and at that time diesel could be seen escaping from the hose.”

The court heard that pumping activities were immediately stopped and the relevant authorities informed.

Department of Energy and Climate Change (DECC) investigators found two damaged sections of hose, which had not be fully inspected before starting operations due to the way the bunkering station was set up.

They found “hand-sized” damage on the hoses and also discovered they were “bulging and deformed in places”.

The Crown narrative added: “In DECC’s opinion, the defective areas of hose could not have been missed had there been an adequate visual inspection of the hose prior to the bunkering
operation.”

Prosecutors said that concerns had first been raised about the bunkering stations, where the hoses were stored, nine years earlier.

And just three months earlier in 2013, the DECC had identified problems with bunkering hoses on the Brent Bravo after inspectors found kinked hoses. Shell was ordered to carry out a review at that time.

Sheriff Kenneth Stewart fined the company £6,650, reduced from the maximum possible of £10,000 due to the early guilty plea.

SOURCE

RELATED

Shell ‘ignored accident warning’: 14 June 2006

This website and sisters royaldutchshellgroup.com, shellnazihistory.com, royaldutchshell.website, johndonovan.website, and shellnews.net, are owned by John Donovan. There is also a Wikipedia segment.

Leave a Reply

Your email address will not be published. Required fields are marked *

This site uses Akismet to reduce spam. Learn how your comment data is processed.

Comment Rules

  • Please show respect to the opinions of others no matter how seemingly far-fetched.
  • Abusive, foul language, and/or divisive comments may be deleted without notice.
  • Each blog member is allowed limited comments, as displayed above the comment box.
  • Comments must be limited to the number of words displayed above the comment box.
  • Please limit one comment after any comment posted per post.